Clarke CPE130SS Service Manual

Thernamic GS Single Compressor Compact Heat Pump Installation & Commissioning PLEASE RETAIN THESE INSTRUCTIONS WITH THE PRODUCT.

10 4.3 Radiators. Space heating only The following section includes typical s

11 4.4.1 Type of DHW Tank The larger size the coil within the tank, the be

12 Vent-Axia Supply Vent-Axia Supply Fig 5 Underfloor with a single manifold

13 Fig 7 Heat Pump with DHW Schematic Hot water out to faucetsImmersion heat

14 4.5 Mechanical Installation 4.5.1 Locating the Heat Pump Decide on a suit

15 4.5.3 Installation of the heat pump Ideally the heat pump should be plac

16 i. Unscrew the 4 x 5mm hex-socket screws, 2 on either side of the front p

17 4.6 Electrical Installation The Vent-Axia Compact heat pump range is avai

18 4.6.1 Single Phase 4.6.1.1 Single Underfloor Control Unit In all wirin

19 4.6.1.2 Multiple Underfloor Control Units 4.6.1.3 Radiator with Thermos

2 Contents Page Section Description Page 1... Notes she

20 400Vac 50Hz Power Supply DHW time clock DHW valve Fault Reverse cycle Hea

21 4.6.3 Weather Compensation (Optional) All Vent-Axia Compact Heat Pumps a

22 5. Commissioning After all mechanical and electrical work has been complet

23 iii. Place a filter such as a kitchen sieve over the pipe returning wate

24 should be flowing through the heat pump or through the other slinkies. The

25 iv. Open the valve V1 to the heat pump and start the purge pump to circu

26 The sequence of valve operation for a single manifold is slightly differen

27 vi. When all the air has been removed reduce the level of water in the b

28 5.1.6 Reassembling the Heat Pump i. Ensure all tools and materials are re

29 5.2 Heat Pump Operation Prior to use: - i. Turn off the power supply at

3 Contents Page Section Description Page 5... Commissi

30 5.4 Altering the flow temperature from the heat pump Each heat pump has a

31 A flashing error code may appear if there is a fault with the heat pu

32 30oC the actual flow temperature out of the heat pump is approximately 35o

33 6. Fault Finding Many faults which occur on commissioning are found to be

34 7. RTB and Extended Warranty Statement All Vent-Axia heat pumps have a tw

35 8. Antifreeze COSHH Sheet

36

37 9. Heat Pump Settings Sheet Type of ground arrays Ground Arrays purged

abc Head Office: Fleming Way, Crawley, West Sussex, RH10 9YX. Tel: 01293 526062 Fax: 01293 551188 UK NATIONAL CALL CENTRE, Newton Road, Crawley, Wes

4 Notes:- ———————————————————————————————————————————————————————————————————

5 2. Safety information Safe operation of this unit can only be guaranteed

6 3. General Product Information This manual explains how to install and com

7 3.2 Vent-Axia Compact Technical Details—Single Compressor Nominal Thermal

8 4. Installation Note: Before actioning any installation observe the 'S

9 4.2.1 Underfloor with a single manifold. Space heating only 4.2.2 Underflo